1988 Ford Aerostar Recalls

1. Recall Description

   EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

   Possible Effects

   LOSS OF BRAKING CAN RESULT.

   Action

   AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.

   Notes

   OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING APRIL 1998.OWNERS WHO DO NOT RECEIVE THE FREE ROTORS WITHIN A REASONABLE TIME SHOULD CONTACT AIMCO AT 815-759-7935.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   -

   Vehicles Affected

   23500

2. Recall Description

   VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.

   Possible Effects

   IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

   Action

   DEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.

   Notes

   OWNER NOTIFICATION BEGAN DECEMBER 9, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   1987-10-01 - 1989-11-30

   Vehicles Affected

   140000

3. Recall Description

   SOME LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE IN EITHER THE OPEN OR CLOSED POSITION.

   Possible Effects

   IF A BALL STUD FRACTURES, THE LIFTGATE WILL NOT REMAIN INTHE OPEN POSITION. BODILY INJURY COULD RESULT IF THE LIFTGATE DROPS WHILESOMEONE IS UNDER IT.

   Action

   REPLACE THE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS.

   Notes

   SYSTEM: REAR LIFTGATE.VEHICLE DESCRIPTION: VANS BUILT AT THE ST. LOUIS ASSEMBLY PLANT.

   Recall Manufacture Dates

   1987-04-01 - 1988-01-01

   Vehicles Affected

   112000

4. Recall Description

   VEHICLES EQUIPPED WITH TRAILER TOW PACKAGE HAVE A TRAILER TAILLIGHT RELAY ASSEMBLY THAT CONTAINS WIRES OF SMALLER GAUGE THAN THE FUSE LINK WHICH PROTECTS THE CIRCUIT.

   Possible Effects

   SHOULD A SHORT CIRCUIT OCCUR IN THE WIRING WITHIN THERELAY OR IF WATER INTRUSION OCCURS THE SMALLER GAUGE WIRE IN THE RELAY WILLFUNCTION AS A FUSE LINK AND OVERHEAT. THE POSSIBILITY EXISTS FOR A FIRE IF THEWIRES ARE EXPOSED TO COMBUSTIBLE MATERIALS.

   Action

   INSTALLATION OF A RELAY WITH WIRES OF GAUGE ADEQUATE TO PROTECT THE CIRCUIT.

   Notes

   SYSTEM: ELECTRICAL.VEHICLE DESCRIPTION: MULTI PURPOSE VEHICLE VAN, EQUIPPED WITH OPTIONAL TRAILERTOW PACKAGE.

   Recall Manufacture Dates

   1985-05-01 - 1988-03-01

   Vehicles Affected

   60000

5. Recall Description

   THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

   Possible Effects

   THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

   Action

   DEALERS WILL REPLACE THE IGNITION SWITCH.

   Notes

   SYSTEM: ELECTRICAL; IGNITION SWITCH. VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES AND LIGHT DUTY TRUCKS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1987-08-01 - 1992-09-30

   Vehicles Affected

   7900000