HowTune

1986 Ford Bronco Ii Recalls

  1. Recall Description

    WIRING FOR THE POWER LUMBAR SEAT SYSTEM WAS ROUTED DIRECTLY BENEATH THE SEAT CUSHION SPRINGS AND MAY BE ABRADED BY THE SPRINGS.

    Possible Effects

    THIS COULD RESULT IN A SHORT CIRCUIT WHICH MAY CREATESUFFICIENT HEAT TO START A FIRE IN THE SEAT CUSHION PAD AND/OR TRIM COVER.

    Action

    INSTALL A FUSE WITHIN THE POWER LUMBAR ELECTRICAL CIRCUIT.

    Notes

    SYSTEM: WIRING FOR POWER LUMBAR SEATS.VEHICLE DESCRIPTION: MULTIPURPOSE VEHICLES AND TRUCKS EQUIPPED WITH POWER LUMBARSEAT ADJUSTERS IN THE FRONT SEATS.

    Recall Manufacture Dates

    1985-05-01 - 1986-07-01

    Vehicles Affected

    90000

  2. Recall Description

    SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

    Possible Effects

    COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

    Action

    INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

    Notes

    SYSTEM: FUEL LINE COUPLINGVEHICLE DESCRIPTION: PASSENGER CARS AND LIGHT TRUCKS EQUIPPED WITH FUELINJECTION.

    Recall Manufacture Dates

    1985-07-01 - 1987-08-01

    Vehicles Affected

    3600000

  3. Recall Description

    THE ELECTRONIC ENGINE CONTROL WIRING HARNESS INSULATION MAY BE DAMAGED DUE TO COPPER SPIKES PRODUCED DURING THE WELDING OF ITS WIRES. THIS CREATES A POTENTIAL FOR A SHORT CIRCUIT BETWEEN THE WIRES WHICH ENERGIZE THE FUEL PUMP, CAUSING SOME FUEL INJECTORS TO OPEN, DISCHARGING FUEL INTO THE ENGINE. CONSEQUENCE OF DEFECT: FUEL DISCHARGED INTO THE ENGINE WOULD EVENTUALLY LEAK THROUGH THE EXHAUST SYSTEM TO THE GROUND. THIS COULD RESULT IN A FIRE IF A SOURCE OF IGNITION IS PRESENT.

    Possible Effects

    Action

    REPAIR WIRING HARNESS, CHECK ENGINE AND CATALYST FOR DAMAGE.

    Notes

    VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 2.9 LITER ENGINE. SYSTEM: ELECTRONIC ENGINE CONTROL WIRING HARNESS.

    Recall Manufacture Dates

    1985-08-01 - 1985-08-01

    Vehicles Affected

    7886

  4. Recall Description

    NYLON FUEL LINES ON THE FUEL RETURN SIDE OF THE FUEL PRESSURE REGULATOR ASSEMBLY MAY CRACK. CONSEQUENCE OF DEFECT: FUEL LINE COULD LEAK AND, IF AN IGNITION SOURCE IS PRESENT, CREATE THE POTENTIAL FOR A FIRE.

    Possible Effects

    Action

    REPLACE NYLON FUEL HOSES WITH RUBBER HOSES.

    Notes

    SYSTEM: FUEL LINES.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 2.9 LITER V-6 ENGINES.

    Recall Manufacture Dates

    1985-08-01 - 1985-10-01

    Vehicles Affected

    30564

All bronco-ii Recalls

Other Ford Recalls