1984 Ford Econoline Recalls

1. Recall Description

   VEHICLES ARE SUBJECT TO EXCESSIVE UNDERHOOD TEMPERATURES AND FUEL SYSTEM PRESSURES IN SEVERE DUTY APPLICATIONS.

   Possible Effects

   THIS CREATES POTENTIAL FOR FUEL EXPULSION FROM THE FUELFILLER PIPE WHICH IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN AFIRE.

   Action

   INSTALL MODIFICATION KITS TO MINIMIZE POSSIBILITY OF FUEL EXPULSION AND TO SHIELD UNDERBODY COMPONENTS FROM EXHAUST SYSTEM HEAT.

   Notes

   SYSTEM: FUELVEHICLE DESCRIPTION: 1983 THROUGH 1987 E250, E350, CLUB WAGONS AND ECONOLINEVANS AND CHASSIS EQUIPPED WITH 7.5 AND 1985 THROUGH 1987 E250, E350, CLUB WAGONSAND ECONOLINE VANS EQUIPPED WITH 5.8 LITER ENGINES.

   Recall Manufacture Dates

   1983-08-01 - 1987-08-01

   Vehicles Affected

   188000

2. Recall Description

   FUEL LEAK AT THE TOP OF THE FRONT FUEL TANK IN THE AREA OF THE VAPOR VALVE GROMMET. GROMMET MAY SPLIT DUE TO COMPRESSIVE LOAD WHEN INSTALLED IN THE FUEL TANK.

   Possible Effects

   FUEL MAY LEAK FROM VAPOR VALVE AND BECOME THE SOURCE OFFUEL FOR A FIRE.

   Action

   INSTALLATION OF A NEWLY DESIGNED VAPOR VALVE GROMMET.

   Notes

   SYSTEM: FUEL/TANK VAPOR VALVE.VEHICLE DESCRIPTION: AMBULANCE, ECONOLINE E350 VANS AND CUTAWAY CHASSIS WITH7.5 LITER ENGINES.

   Recall Manufacture Dates

   1983-08-01 - 1987-08-01

   Vehicles Affected

   250

3. Recall Description

   EXPULSION OF FUEL DUE TO OVERPRESSURIZATION.

   Possible Effects

   FUEL OR FUEL VAPORS IN THE PRESENCE OF AN IGNITIONSOURCE CAN CAUSE A FIRE.

   Action

   MODIFICATION OF THE BASE FUEL VENTING AND EMISSION CONTROL SYSTEM TO REDUCE OPERATING TEMPERATURES AND FUEL SYSTEM PRESSURES.

   Notes

   SYSTEM: FUEL.VEHICLE DESCRIPTION: AMBULANCE, FORD ECONOLINE E350 CUTAWAY CHASSIS AND VANS,EQUIPPED WITH 7.5 LITER ENGINES.

   Recall Manufacture Dates

   1983-08-01 - 1987-08-01

   Vehicles Affected

   16000

4. Recall Description

   WHEN FRONTALLY IMPACTED INTO A FIXED BARRIER AT 30 MPH, AS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 301, THE LEFT FRAME RAILS OF SUCH VEHICLES MAY DISPLACE INBOARD, PINCHING THE FUEL/WATER SEPARATOR CANISTER BETWEEN THE FRAME RAIL AND ENGINE SUFFICIENTLY TO DISPLACE THE FUEL/WATER SEPARATOR DRAIN ROD, ALLOWING THE CONTENTS OF THE CANISTER TO DRAIN. CONSEQUENCE OF DEFECT: FUEL LEAK DURING OR AFTER A CRASH INCREASES THE POSSIBILITY OF A FIRE.

   Possible Effects

   Action

   INSTALL A CANISTER SHIELD, A REVISED DESIGN DRAIN ROD SHIELD, AND MODIFY FUEL/WATER SEPARATOR MOUNTING BRACKET.

   Notes

   VEHICLE DESCRIPTION: VANS, SUPER VANS, SUPER WAGONS AND CLUB WAGONS EQUIPPEDWITH 6.9 LITER DIESEL ENGINES. SYSTEM: FUEL/FMVSS 301.

   Recall Manufacture Dates

   1983-03-01 - 1985-04-01

   Vehicles Affected

   8500

5. Recall Description

   THE SECONDARY THROTTLE SHAFT MAY, WITH ACCUMULATED MILEAGE, BECOME CONTAMINATED AND MAY STICK IN A PARTIALLY OPEN POSITION WHILE DRIVING.

   Possible Effects

   CONSEQUENCE OF DEFECT: THIS STICKING COULD RESULT IN A FASTER SPEED THAN INTENDED, POSSIBLY RESUTLING IN AN ACCIDENT.

   Action

   THE PRIMARY TO SECONDARY THROTTLE CLOSURE LINK ON THE CARBURETOR WILL BE REPLACED FREE OF CHARGE.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5.0 LITER ENGINES, AND TRUCKS AND MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.8 OR 7.5 LITER ENGINES; VEHICLES ARE EQUIPPED WITH 4 BARREL CARBURETORS.SYSTEM: FUEL; CARBURETOR SECONDARY THROTTLE CONTROL.

   Recall Manufacture Dates

   1983-08-01 - 1984-03-01

   Vehicles Affected

   85000

6. Recall Description

   SOME VEHICLES MAY HAVE BEEN BUILT WITH IMPROPERLY MANUFACTURED WHEELS. THE WELDS SECURING THE CENTER SECTIONS TO THE RIMS MAY CRACK FROM FATIGUE.

   Possible Effects

   Action

   AFFECTED WHEELS WILL BE REPLACED.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS (VANS) AND MPVS EQUIPPED WITH 16.5 X 6.75SINGLE REAR WHEELS.SYSTEM: SUSPENSION; WHEELS.CONSEQUENCES OF DEFECT: IF THE CRACKING CONTINUES, TIRE PRESSURE MAY BEGRADUALLY LOST, OR THE WHEEL RIM AND TIRE MAY SEPARATE FROM THE VEHICLE. WHEELWOBBLE OR VIBRATION MAY OCCUR BEFORE THE WHEEL AND TIRE SEPARATE FROM THEVEHICLE. LOSS OF TIRE PRESSURE, OR LOSS OF TIRE AND WHEEL COULD CAUSE LOSS OFCONTROL AND AN ACCIDENT.

   Recall Manufacture Dates

   1983-11-01 - 1983-12-01

   Vehicles Affected

   1050

7. Recall Description

   CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

   Possible Effects

   A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

   Action

   FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   -

   Vehicles Affected

   34000