1977 Lincoln Mark V Recalls

1. Recall Description

   THE INVOLVED VEHICLES WERE BUILT WITH AN ALUMINUM REAR BUMPER REINFORCEMENT ATTACHED TO TWO STEEL MOUNTING SURFACES. IN CLIMATES WHERE LARGE AMOUNTS OF ROCK SALT ARE USED, THE ALUMINUM REINFORCEMENT COULD EXPERIENCE CORROSION WHERE IT ATTACHES TO THE VEHICLE.

   Possible Effects

   Action

   DEALER WILL INSPECT ALL INVOLVED VEHICLES FOR DEGREE OF CORROSION. WHERE CORROSION IS SEVERE, THE ALUMINUM REINFORCEMENT WILL BE REPLACED WITH ONE MADE OF STEEL. WHERE CORROSION IS NOT SEVERE, DEALER WILL INSTALL INSULATION MATERIALS BETWEEN THE ALUMINUM AND THE STEEL COMPONENTS. THIS WILL BE DONE AT NO COST TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; REAR BUMPER REINFORCEMENT.CONSEQUENCES OF DEFECT: CORROSION CAN WEAKEN THE REINFORCEMENT, THUSPOTENTIALLY RESULTING IN SEPARATION OF THE REAR BUMPER FROM THE VEHICLE. THISWOULD PRESENT A TRAFFIC HAZARD TO ONCOMING VEHICLES.

   Recall Manufacture Dates

   1977-09-01 - 1978-05-01

   Vehicles Affected

   125000

2. Recall Description

   SOME OF THE INVOLVED VEHICLES MAY HAVE DEFECTIVE CARBURETORS IN WHICH, UNDER CERTAIN CIRCUMSTANCES, THE SECONDARY THROTTLE PLATES MAY STICK OPEN.

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE CARBURETOR AT NO CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH 460 CIDENGINES.SYSTEM: THROTTLE LINKAGES; THROTTLE LEVER.CONSEQUENCES OF DEFECT: IN THE EVENT OF THROTTLE STICKING, THE VEHICLE MAYCONTINUE TO ACCELERATE AFTER THE ACCELERATOR PEDAL IS RELEASED. CONTINUOUSACCELERATION COULD OCCUR WITHOUT WARNING AND LEAD TO A LOSS OF VEHICLE CONTROLAND AN ACCIDENT.NOTE: THE LIKELIHOOD OF THE CONDITION OCCURRING CAN BE REDUCED BY AVOIDING FULLOR NEARLY FULL DEPRESSIONS OF THE ACCELERATOR PEDAL AS DURING HIGH ACCELERATIONOR FULL POWER OPERATIONS.

   Recall Manufacture Dates

   -

   Vehicles Affected

   16000

3. Recall Description

   THE INVOLVED VEHICLES WERE FITTED WITH TILT STEERING COLUMNS CONTAINING TRANSMISSION CONTROL INSERTS INTENDED FOR TRUCKS RATHER THAN PASSENGER VEHICLES. THIS MAY CAUSE THE TRANSMISSION SELECTOR POINTER TO BE MISALIGNED AND THE POSSIBILITY OF STARTING THE ENGINE WHEN THE SELECTOR IS BETWEEN THE NEUTRAL (N) AND DRIVE (D) DETENTS AND THE TRANSMISSION IS IN DRIVE.

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE TRANSMISSION SHIFT CONTROL INSERT, WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH TILT STEERING COLUMNS ANDAUTOMATIC TRANSMISSIONS.SYSTEM: POWER TRAIN; TRANSMISSION CONTROL INSERTS, STEERING COLUMN.CONSEQUENCES OF DEFECT: SHOULD THE ENGINE START WITH THE TRANSMISSION IN DRIVE,THE VEHICLE COULD UNEXPECTEDLY MOVE FORWARD AND AN ACCIDENT AND PERSONAL INJURYCOULD RESULT.NOTE: PRIOR TO CORRECTIVE ACTION, DRIVER SHOULD BE CAREFUL TO START THE ENGINEONLY WHEN THE GEAR SELECTOR INDICATES PARK (P).

   Recall Manufacture Dates

   1977-07-01 - 1977-08-01

   Vehicles Affected

   9000

4. Recall Description

   Possible Effects

   Action

   Notes

   FORD CAMPAIGN NO 204.POSSIBILITY THAT THE INTERMITTENT WINDSHIELD WIPER MAYHAVE BEEN PRODUCED WITH WINDSHIELD WASHER THAT MAY NOT MEET THE REQUIREMENTS OFS4.2.1 OF OF FMVSS NO.104.IT HAS BEEN DETERMINED DUE TO DESIGN ERROR,THE WINDSHIELD WIPER CONTROL KNOB, WITH USE, MAY BOTTOM-OUT AGAINST THE WASHERSWITCH BEZEL BEFORE THE WASHER CIRCUIT IS ACTIVATED.(CORRECT BY INSPECTINGAND REWORKING WINDSHIELD WIPER TO MEET THE REQUIREMENTS OF FMVSS NO.104).PASSENGER VEHICLE.

   Recall Manufacture Dates

   -

   Vehicles Affected

   2063