1990 Pontiac Trans Sport Recalls

1. Recall Description

   THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH FRONT BUCKET SEATS. THE FRONT SEAT RECLINER MECHANISM LOWER BOLTS CAN LOOSEN. A LOOSE BOLT COULD FATIGUE AND BREAK, RESULTING IN THE SEAT BACK FALLING REARWARD.

   Possible Effects

   THE SEAT COULD SUDDENLY FALL BACKWARD, DISTRACTING THE DRIVER, INCREASING THE RISK OF A CRASH.

   Action

   DEALERS WILL TIGHTEN OR REPLACE THE BOLTS AT NO CHARGE TO THE OWNERS. THIS POLICY IS IN EFFECT UNTIL JUNE 30, 2002.

   Notes

   GM HAS DECIDED TO CONDUCT A SPECIAL POLICY TO TIGHTEN OR REPLACE THE FRONT SEAT RECLINER MECHANISM LOWER BOLTS. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

   Recall Manufacture Dates

   -

   Vehicles Affected

   187459

2. Recall Description

   VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.

   Possible Effects

   IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.

   Action

   DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.

   Notes

   OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1989-07-01 - 1990-07-30

   Vehicles Affected

   676535

3. Recall Description

   THE GLOVE COMPARTMENT DOOR WILL NOT REMAIN CLOSED DURING CERTAIN LOAD FORCES ASSOCIATED WITH A VEHICLE CRASH. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 201.

   Possible Effects

   IN THE EVENT OF AN ACCIDENT, THE GLOVE COMPARTMENT DOORMAY OPEN AND RESULT IN OCCUPANT(S) INJURIES FROM CONTACT WITH THE GLOVECOMPARTMENT DOOR.

   Action

   REPLACE THE CURRENT UPPER GLOVE COMPARTMENT DOOR WITH A REDESIGNED UPPER GLOVE COMPARTMENT DOOR WHICH INCORPORATES A POSITIVE LATCH TO KEEP THE DOOR CLOSED SHOULD A VEHICLE CRASH OCCUR.

   Notes

   SYSTEM: GLOVE COMPARTMENT; FMVSS 201.VEHICLE DESCRIPTION: PASSENGER MINI-VANS.

   Recall Manufacture Dates

   1988-08-01 - 1991-07-01

   Vehicles Affected

   95897

4. Recall Description

   A RIGHT HAND SEAT/SHOULDER BELT RETRACTOR MAY HAVE BEEN INSTALLED IN THE SECOND ROW LEFT HAND SEAT POSITION (DIRECTLY BEHIND DRIVER).

   Possible Effects

   THE INCORRECT RETRACTOR MAY CAUSE THE BELTS TO LOCK UPIF THE VAN IS PARKED ON A STEEP GRADE. AS A RESULT OF THIS, THE OCCUPANT COULDNOT EXTEND THE BELT FOR USE.

   Action

   REPLACE SHOULDER BELT ASSEMBLY.

   Notes

   SYSTEM: SAFETY BELT ASSEMBLY; FMVSS 209.VEHICLE DESCRIPTION: PASSENGER VANS WITH GREY INTERIORS.

   Recall Manufacture Dates

   1990-04-01 - 1990-05-01

   Vehicles Affected

   400

5. Recall Description

   THE REAR MODULAR SEAT FRAME HOLD-DOWN HOOKS MAY NOT MEET THE REQUIRED PULL FORCE AT THE REAR SET ANCHORAGE.

   Possible Effects

   VEHICLES WOULD NOT CONFORM TO FMVSS 207.

   Action

   REPLACE REAR HOLD DOWN HOOKS AND PIVOT RIVETS WITH HEAT TREATED HARDWARE.

   Notes

   SYSTEM: REAR SEAT ANCHORAGE / FMVSS 207VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLE.

   Recall Manufacture Dates

   1989-06-01 - 1989-09-01

   Vehicles Affected

   343