1993 Pontiac Trans Sport Recalls

1. Recall Description

   VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.

   Possible Effects

   VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.

   Action

   DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.

   Notes

   SYSTEM: POWER TRAIN; TRANSMISSION; AUTOMATIC; COOLING UNIT AND LINES. VEHICLE DESCRIPTION: PASSENGER MINI-VANS WITH 3.8L ENGINE AND 4-SPEED AUTOMATIC TRANSMISSIONS AND PASSENGER VEHICLES WITH L27 OR L67 ENGINE AND 4T60E AUTOMATIC TRANSMISSIONS AND SOLD OR REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, VERMONT, WEST VIRGINIA, WISCONSIN AND WYOMING.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   -

   Vehicles Affected

   585182

2. Recall Description

   THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME POSITION.

   Possible Effects

   IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.

   Action

   DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.

   Notes

   SYSTEM: INTERIOR SYSTEMS; SHOULDER BELTS.VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH OPTIONAL POWER SLIDING DOOR.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-424-9393; PONTIAC SERVICE CENTER AT1-800-762-2737; OR OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1992-11-01 - 1994-03-01

   Vehicles Affected

   5294

3. Recall Description

   VEHICLE FAILS TO CONFORM TO FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE SAFETY BELT OF THE LEFT THIRD ROW SEAT ON THE SIX PASSENGER VAN AND THE CENTER SECOND ROW SEAT OF THE SEVEN PASSENGER VAN MAY LOCK UP AND CANNOT BE WITHDRAWN FROM THE RETRACTOR.

   Possible Effects

   CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANTS OF THESE SEATS WILL NOT BE ABLE TO USE THE AFFECTED BELT. IN THE EVENT OF A VEHICLE CRASH, UNBELTED OCCUPANTS ARE AT INCREASED RISK OF INJURY.

   Action

   OWNERS ARE BEING ASKED TO INSPECT THEIR VEHICLES TO DETERMINE IF THE SUSPECT RETRACTOR EXHIBITS A LOCKUP CONDITION. BASED ON THIS INSPECTION, DEALERS WILL REPLACE THE SAFETY BELTS IF THE BELT LOCKS UP. REPLACEMENT OF THE SUSPECT SAFETY BELT WILL BE AVAILABLE TO CONSUMERS FOR THE LIFE OF THE VEHICLE.

   Notes

   SYSTEM: INTERIOR SYSTEMS; SEAT BELTS; LAP; REAR.VEHICLE DESCRIPTION: SIX AND SEVEN PASSENGER VANS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGEOR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020; PONTIAC SERVICE CENTER AT1-800-762-2737; AND OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT1-800-424-9393.

   Recall Manufacture Dates

   1991-06-01 - 1993-06-01

   Vehicles Affected

   157740